Ferris Industries Automobile Accessories 5049751 User Manual

Trailer Hitch Kit  
Part No. 5049751  
Installation  
Instructions  
Fits Simplicity:  
1694454  
Fits Snapper:  
5091000  
1694455  
5091001  
1694460  
This kit will install a trailer hitch on the rear  
bumper.  
Kit Contents:  
Part No. Qty. Description  
2849754  
2849791  
5049753  
7091497  
7091297  
7090122  
1
1
1
2
2
4
Trailer Hitch Plate  
Support Plate  
Warning Decal  
3/8-16 x 1-1/2”Bolt  
3/8-16 Hex Nylon Lock Nut  
3/8” SAE Washer  
Flush  
A
Figure 1. Clamp Hitch Plate In Place  
A. Hitch Plate  
WARNING  
Before beginning any service work turn off the  
PTO, set the parking brake, turn off the ignition,  
and disconnect the spark plug wire(s).  
E
B
Tools Required:  
(1) Drill & 7/16” drill bit  
(1) 3/8” drive ratchet & 9/16” socket  
(1) 9/16” combination wrench  
(1) Prick punch & hammer  
(1) Marker or pencil  
D
C
B
(1) Vise-Grip clamp or C-clamp  
INSTALLATION  
A
1. Locate the holes on the bottom edge of the bumper.  
If the bumper does not have pre-existing holes, con-  
tinue with Step 2. If the bumper has holes, skip to  
Step 4.  
Figure 2. Install Hitch Plate  
A. 3/8-16 x 1-1/2” Bolts  
B. 3/8” SAE Washers  
C. Hitch Plate  
D. Support Plate  
E. 3/8-16 Nylon Lock Nuts  
2. Place the hitch plate (A, Figure 1) on the bottom  
edge of the bumper. Center the plate side-to-side,  
and flush with the inside edge. Clamp in place.  
3. Using the holes in the hitch plate as a template,  
mark the bumper with either a prick punch or mark-  
er/pencil. Remove the mounting plate and drill 7/16”  
holes through the bumper.  
4. Install the tow hitch plate and support plate (C & D  
Figure 2) on the bumper and install the 3/8-16 x 1-  
1/2” bolts, washers and flange nuts (A,B & E).  
Tighten hardware securely.  
5. Clean the outside surface of the bumper, between  
the hitch plate and rear shield with a mild cleaning  
solution to remove any dirt or grease and dry. Apply  
the warning decal as shown in Figure 3.  
Figure 3. Install Warning Decal  
49752  
Rev. 4/2004  
© Copyright 2004 Ferris Industries. All Rights Reserved.  
TP 200-7153-00-SK-SN  
 

Earlex Ventilation Hood VAP75 User Manual
Electro Voice Portable Speaker LS12A User Manual
Euphonix Switch SH612 User Manual
EverFocus Security Camera EPHD04+ User Manual
Extron electronic Network Hardware FOX AEX 104 User Manual
Faber Ventilation Hood CRISTAL HC User Manual
Freecom Technologies Air Conditioner RCS S3000T User Manual
Frigidaire Air Conditioner FRA124HT1 User Manual
Frymaster Fryer 8196428 User Manual
Fusion Speaker NVSW12 User Manual